Vehicles › Gillig › Gillig LOW Floor
2012 Gillig LOW Floor
NHTSA lists 11 recall campaigns for the 2012 Gillig LOW Floor, covering electrical system, exterior lighting and seats, and 0 consumer complaints received since 1995.
No consumer complaints for this model year are in the NHTSA file.
Complaints are consumer reports and have not been verified by NHTSA. Recall text is the manufacturer's Part 573 report as filed with NHTSA. Complaint file through 15 May 2019; recall file through 29 Sep 2026.
Recalls by model year:
Recall campaigns
Defect, as filed: Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
Consequence: With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Remedy: Gillig will notify owners, and dealers will replace the circuit breakers, free of charge. The recall began April 24, 2020. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain 2012-2018 Gillig Low Floor vehicles. The front and rear turn signals on these vehicles may flash at different rates, potentially confusing other drivers of the vehicle's intention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The mismatched flashing may confuse other drivers, increasing the risk of a crash.
Remedy: Gillig will notify the owner of the buses, and dealers will reprogram the turn signals with new software, free of charge. The recall began August 30, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The reduced visibility of the turn signals can increase the risk of a crash.
Remedy: Gillig will notify owners, and dealers will update the software that controls the turn flash rate, free of charge. The recall began on August 2, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Filed by Gillig LLC; components: exterior lighting:turn signal:flasher unit; exterior lighting:turn signal.
Defect, as filed: Gillig LLC (Gillig) is recalling certain model year 1997-2017 Low Floor transit buses. The front turn signals installed on standard profile (non-BRT) buses may not be sufficiently visible to other drivers or pedestrians. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The reduced visibility of the turn signals may increase the risk of a crash.
Remedy: Gillig will notify owners, and dealers will install turn signals that have increased visibility. The recall began June 7, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain model year 2012-2016 Lowfloor diesel-electric hybrid vehicles manufactured March 6, 2012, to June 7, 2016. The affected vehicles are equipped with stop lamp activation that may inadvertently flash the rear brake lights. As such, these vehicles do not comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Assoc. Equipment."
Consequence: Flashing brake lights may cause confusion to other drivers, increasing the risk of a crash.
Remedy: Gillig will notify owners, and dealers will install a new software update, free of charge. The recall began on July 2016. Owners may contact Gillig customer service at 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain model year 2010-2015 Low Floor transit buses manufactured April 1, 2010 to October 30, 2015, equipped with Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket.
Consequence: If the seatbelt anchorage assembly separates from the J-Bracket, the bus driver may not be properly restrained in the event of a crash increasing their risk of injury.
Remedy: Gillig will notify the owners, and dealers will inspect the seats to determine if welds are missing. Any J-Bracket that is missing welds will be removed and replaced, free of charge. The recall began on March 1, 2016. Owners may contact Gillig customer service at 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain model year 2010-2015 Low Floor transit buses manufactured April 13, 2010, to June 12, 2015. Due to the routing of the grid heater electrical power cable, the cable may chafe against a fuel injector hard line.
Consequence: If the electrical power cable rubs against the injector fuel line, the cable may short circuit or the fuel line may leak fuel. Either possibility increases the risk of a fire.
Remedy: Gillig will notify owners, and dealers will inspect the grid heater power cable/hard injector fuel line for wear, and will properly route and support the grid heater power cable, free of charge. The recall began on July 17, 2015. Owners may contact Gillig customer service at 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain model year 2010-2015 Lowfloor vehicles manufactured August 26, 2010, to April 30, 2015. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Consequence: If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Remedy: Gillig will notify owners, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 2, 2015. Owners may contact Gillig customer service at 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig, LLC (Gillig) is recalling certain model year 2007-2014 Lowfloor transit buses manufactured September 26, 2007, through January 24, 2014. In the affected vehicles, the engine oil sampling hose may leak oil due to being routed too closely to hot engine exhaust components.
Consequence: If the sampling hose leaks oil in the presence of hot engine engine exhaust components, there is an increased risk of fire.
Remedy: Gillig will notify owners, and dealers will inspect the oil sampling hose. If the hose is routed too closely, the hose will be removed, replaced and rerouted to provide appropriate clearance of the hot components. The recall is expected to begin in early August 2014. Owners may contact Gillig customer service at 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC (Gillig) is recalling certain model year 2012-2014 Lowfloor transit buses manufactured October 15, 2012, through March 26, 2014, and equipped with electrical harnesses with overmolded J1939 connectors and non-insulated drain wires. The harnesses do not have heat shrink tubing on the drain wire and the overmold may not have sufficient resistance to water or corrosive chemical entry to the connectors.
Consequence: If the terminals corrode, there may be an intermittent electrical connection and possibly cause disruption or loss of the J1939 communication, resulting in interruptions of the engine, transmission, ABS and body controllers, increasing the risk of a crash.
Remedy: Gillig will notify owners, and dealers will replace the overmold connector, and install heat shrink tubing on the connector/cable junction, free of charge. The recall began in June 2014. Owners may contact Gillig customer service at 1-800-735-1500.
Filed by Gillig LLC.
Defect, as filed: Gillig LLC is recalling certain model year 2010-2014 Lowfloor transit buses manufactured August 26, 2010, through February 14, 2014, and equipped with certain Cummins Westport model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
Consequence: The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire.
Remedy: Cummins Inc. and Cummins Wesport Inc. will notify owners, and dealers will upload a new ECM calibration, free of charge. The recall began on March 20, 2014. Owners may contact Gillig LLC at 1-510-785-1500 or Cummins Inc. at 1-800-343-7357.
Filed by Gillig LLC.
Each entry links to the NHTSA record. NHTSA states that safety recall repairs are free of charge at an authorised dealer; check a specific vehicle by VIN at nhtsa.gov/recalls.
Complaints by component
No consumer complaints for this model year are in the NHTSA file.
Investigations
No NHTSA Office of Defects Investigation action in the current file names this model year.
Other Gillig LOW Floor model years
| Model year | Recalls | Complaints | Units in campaigns |
|---|---|---|---|
| 1997 | 6 | 0 | 25,630 |
| 1998 | 10 | 0 | 31,441 |
| 1999 | 10 | 0 | 29,575 |
| 2000 | 10 | 1 | 29,575 |
| 2001 | 10 | 0 | 53,116 |
| 2002 | 8 | 0 | 50,143 |
| 2003 | 9 | 1 | 46,858 |
| 2004 | 8 | 0 | 46,130 |
| 2005 | 4 | 0 | 45,649 |
| 2006 | 5 | 0 | 45,898 |
| 2007 | 8 | 0 | 44,909 |
| 2008 | 5 | 1 | 44,373 |
| 2009 | 5 | 0 | 44,373 |
| 2010 | 9 | 0 | 59,952 |
| 2011 | 10 | 0 | 59,649 |
| 2012 | 11 | 0 | 69,520 |
| 2013 | 17 | 0 | 75,509 |
| 2014 | 23 | 0 | 77,694 |
| 2015 | 19 | 0 | 76,611 |
| 2016 | 20 | 1 | 73,720 |
| 2017 | 15 | 0 | 74,752 |
| 2018 | 13 | 0 | 52,743 |
| 2019 | 12 | 0 | 23,498 |
| 2020 | 14 | 0 | 23,049 |
| 2021 | 12 | 0 | 13,258 |
| 2022 | 11 | 0 | 14,101 |
| 2023 | 15 | 0 | 15,405 |
| 2024 | 9 | 0 | 6,449 |
| 2025 | 4 | 0 | 4,093 |
| 2026 | 2 | 0 | 3,992 |
Model years with a single campaign and fewer than 25 complaints have no page here; the NHTSA link opens the agency's record for that year.
All Gillig LOW Floor model years · Gillig: 7 model lines
Questions and answers
How many recalls does the 2012 Gillig LOW Floor have?
11 NHTSA recall campaigns name this model year; the most recent, 20V179000, was reported to NHTSA on 25 Mar 2020 and concerns electrical system:wiring:fuses and circuit breakers. Across all model years the Gillig LOW Floor line has 90 campaigns.
Is there an open NHTSA investigation into the 2012 Gillig LOW Floor?
No NHTSA investigation in the current file names this model year.
What component do owners of the 2012 Gillig LOW Floor complain about most?
No complaints for this model year are in the NHTSA file.
How do I get a recall repaired?
NHTSA states that safety recall repairs are performed free of charge by the manufacturer's authorised dealers. Each campaign's remedy text above is the manufacturer's statement as filed with NHTSA. Check your VIN at nhtsa.gov/recalls to see whether a specific vehicle has an unrepaired recall.
Where does this data come from?
NHTSA's Office of Defects Investigation recall, complaint and investigation flat files, public domain, downloaded 29 Sep 2026. Complaint counts are unique complaint numbers per make, model and model year; component figures count each component a complaint names. The NHTSA record linked from each campaign is authoritative.
Provenance
Source: National Highway Traffic Safety Administration, Office of Defects Investigation flat files (recalls, complaints, investigations), public domain, files dated 29 Sep 2026 (recalls) and 15 May 2019 (complaints). Complaints since 1 Jan 1995. Counts are unique complaint numbers per make, model and model year; per-1,000 rates divide a component's mentions by all mentions for the same group. Errors in processing are corrected at the next daily build; see corrections and the methodology.