Recall Register

2006 Gillig LOW Floor: recalls and complaints

NHTSA lists 5 recall campaigns for the 2006 Gillig LOW Floor. The newest campaign is 18V418000. NHTSA received the report on 20 Jun 2018. The NHTSA record gives the component Exterior Lighting / Turn Signal / Flasher Unit. NHTSA has no complaint on file for this model year.

The NHTSA recall file shows no do-not-drive advisory and no park-outside advisory on these campaigns.

This page cannot show if a recall applies to one vehicle. The NHTSA VIN lookup shows the unrepaired recalls of one vehicle.

Remedy of the newest campaign, 18V418000, in the NHTSA record

Gillig will notify owners, and dealers will update the software that controls the turn flash rate, free of charge. The recall began on August 2, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA VIN lookup

Complaint information entered into NHTSA’s Office of Defects Investigation vehicle owner's complaint database is used with other data sources to identify safety issues that warrant investigation and to determine if a safety-related defect trend exists.

NHTSA publishes these words. Source: NHTSA Datasets and APIs, section Complaints, read on . Complaint file through . Recall file through .

Since the last update

No tracked figure of this page changed in a data update. What the log tracks

All updates to the register

Recall campaigns

5 campaigns, newest first. 45,898 units in total.

  • 18V418000Exterior Lighting / Turn Signal / Flasher Unit
  • 17V119000Exterior Lighting / Turn Signal
  • 09V368000Interior Lighting
  • 08V008000Service Brakes, Air
  • 06V427000Fuel System, Diesel

  1. 18V418000Received . 25,579 units.

    Exterior Lighting / Turn Signal / Flasher Unit

    Defect, in the NHTSA record
    Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
    Consequence, in the NHTSA record
    The reduced visibility of the turn signals can increase the risk of a crash.
    Remedy, in the NHTSA record
    Gillig will notify owners, and dealers will update the software that controls the turn flash rate, free of charge. The recall began on August 2, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

    Report filed by Gillig LLC. Owner notification date in the NHTSA record: .

  2. 17V119000Received . 17,056 units.

    Exterior Lighting / Turn Signal

    Defect, in the NHTSA record
    Gillig LLC (Gillig) is recalling certain model year 1997-2017 Low Floor transit buses. The front turn signals installed on standard profile (non-BRT) buses may not be sufficiently visible to other drivers or pedestrians. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
    Consequence, in the NHTSA record
    The reduced visibility of the turn signals may increase the risk of a crash.
    Remedy, in the NHTSA record
    Gillig will notify owners, and dealers will install turn signals that have increased visibility. The recall began June 7, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

    Report filed by Gillig LLC. Owner notification date in the NHTSA record: .

  3. 09V368000Received . 1,053 units.

    Interior Lighting

    Defect, in the NHTSA record
    Gillig corporation is recalling certain model year 2001 through 2009 transit buses manufactured between january 2001 and september 2009 equipped with luminator horizon LED side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.
    Consequence, in the NHTSA record
    A short could occur, possibly causing smoke and fire.
    Remedy, in the NHTSA record
    Gillig will notify owners and luminator will repair the buses free of charge. The safety recall began on spetember 29, 2009. Owners may contact luminator at 1-972-516-3033 or gillig field services at 1-800-735-1500.

    Report filed by GILLIG CORPORATION. Owner notification date in the NHTSA record: .

  4. 08V008000Received . 249 units.

    Service Brakes, Air

    Defect, in the NHTSA record
    On certain transit buses equipped with graham-white air dryers, the air dryer timer modules may allow sufficient quantities of moisture to enter and affect the operation of the vehicle air brake system.
    Consequence, in the NHTSA record
    Failure of the air brake system due to moisture could result in a crash.
    Remedy, in the NHTSA record
    Gillig, in conjunction with graham-white, will replace the air dryer timer module on the affected vehicles. The recall began on january 29, 2008. Owners may contact gillig at 1-510-785-1500 or graham-white at 540-387-5620.

    Report filed by GILLIG CORPORATION. Owner notification date in the NHTSA record: .

  5. 06V427000Received . 1,961 units.

    Fuel System, Diesel

    Defect, in the NHTSA record
    On certain transit buses built with cummins isl and isc diesel engines equipped with the cm850 fuel system, the engine high pressure fuel lines, from the engine high pressure pump to the engine fuel rail, are prone to failure.
    Consequence, in the NHTSA record
    Failure of the line introduces high pressure fuel spray into the engine compartment which can ignite when it comes in contact with a hot surface.
    Remedy, in the NHTSA record
    Cummins will install a fuel line bracket to reduce fuel line stress. A new fuel line will be installed when adding the bracket (please see 06e037). Gillig notified customers on november 22, 2006. Customers may contact cummins at 1-800-343-7357 or gillig at 510-264-5031.

    Report filed by GILLIG CORPORATION. Owner notification date in the NHTSA record: .

The campaign number opens the NHTSA record. Each quotation is the text of the NHTSA recall file.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

Complaints by component

The NHTSA complaint file has no complaint for this model year.

Investigations

The NHTSA investigation file has no investigation that names this model year.

Investigation: A study of a possible safety defect by the NHTSA Office of Defects Investigation. An investigation with no closing date in the NHTSA file is open.

Other model years

The number under each year is the number of recall campaigns.

  1. 19976
  2. 199810
  3. 199910
  4. 200010
  5. 200110
  6. 20028
  7. 20039
  8. 20048
  9. 20054
  10. 20065
  11. 20078
  12. 20085
  13. 20095
  14. 20109
  15. 201110
  16. 201211
  17. 201317
  18. 201423
  19. 201519
  20. 201620
  21. 201715
  22. 201813
  23. 201912
  24. 202014
  25. 202112
  26. 202211
  27. 202315
  28. 20249
  29. 20254
  30. 20262

A year without a link has fewer than 2 campaigns and fewer than 25 complaints. It has no page.

Official channels

Cite this page

Recall Register. 2006 Gillig LOW Floor: recalls and complaints. https://recallregister.com/vehicle/gillig/low-floor/2006/. Source: NHTSA Office of Defects Investigation, recall, complaint and investigation files. Data through .

Sources

Source
NHTSA Office of Defects Investigation
Licence
US government work, public domain
Recall file through
29 Sep 2026
Complaint file through
29 Mar 2018
First complaint in the file
1 Jan 1995
Manufacturer in the recall file
Gillig LLC

The NHTSA record is the authority. A complaint count is the number of different complaint numbers for the make, the model and the model year. How the register is made. Report an error.

Questions

How many units are in the recall campaigns for the 2006 Gillig LOW Floor?
45,898 units in 5 campaigns. A campaign can name other models and model years, and its units include them.
How many recall campaigns does the Gillig LOW Floor have for all model years?
NHTSA lists 90 recall campaigns for the Gillig LOW Floor, model years 1997 to 2026. 5 of them name the 2006 model year.
Is an NHTSA investigation of the 2006 Gillig LOW Floor open?
The NHTSA investigation file has no investigation that names this model year.