Recall Register

2011 Toyota RAV4: recalls and complaints

NHTSA lists 11 recall campaigns for the 2011 Toyota RAV4. The newest campaign is 16V596000. NHTSA received the report on 12 Aug 2016. The NHTSA record gives the component Suspension / Rear. NHTSA has no complaint on file for this model year. 1 NHTSA investigation names this model year.

The NHTSA recall file shows no do-not-drive advisory and no park-outside advisory on these campaigns.

This page cannot show if a recall applies to one vehicle. The NHTSA VIN lookup shows the unrepaired recalls of one vehicle.

Remedy of the newest campaign, 16V596000, in the NHTSA record

Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
NHTSA VIN lookup

Complaint information entered into NHTSA’s Office of Defects Investigation vehicle owner's complaint database is used with other data sources to identify safety issues that warrant investigation and to determine if a safety-related defect trend exists.

NHTSA publishes these words. Source: NHTSA Datasets and APIs, section Complaints, read on . Complaint file through . Recall file through .

Since the last update

No tracked figure of this page changed in a data update. What the log tracks

All updates to the register

Recall campaigns

11 campaigns, newest first. 5,282,278 units in total.

  1. 16V596000Received . 337,449 units.

    Suspension / Rear

    Defect, in the NHTSA record
    Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
    Consequence, in the NHTSA record
    Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.

    Report filed by Toyota Motor Engineering & Manufacturing. Manufacturer campaign number Toyota G0V Lexus GLK. Owner notification date in the NHTSA record: .

  2. 16V396000Received . 7,749 units.

    Seats / Front Assembly / Seat Heater/Cooler

    Defect, in the NHTSA record
    Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
    Consequence, in the NHTSA record
    If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
    Remedy, in the NHTSA record
    SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

    Report filed by Southeast Toyota Distributors, LLC. Manufacturer campaign number SET16B. Owner notification date in the NHTSA record: .

  3. 16V096000Received . 1,123,752 units.

    Seat Belts / Rear/Other

    Defect, in the NHTSA record
    Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
    Consequence, in the NHTSA record
    A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
    Remedy, in the NHTSA record
    Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

    Report filed by Toyota Motor Engineering & Manufacturing. Manufacturer campaign number G0F. Owner notification date in the NHTSA record: .

  4. 15V689000Received . 1,814,284 units.

    Visibility / Power Window Devices and Controls

    Defect, in the NHTSA record
    Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
    Consequence, in the NHTSA record
    If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
    Remedy, in the NHTSA record
    Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

    Report filed by Toyota Motor Engineering & Manufacturing. Manufacturer campaign number C0M. Owner notification date in the NHTSA record: .

  5. 15V577000Received . 423,456 units.

    Visibility/Wiper

    Defect, in the NHTSA record
    Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
    Consequence, in the NHTSA record
    Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
    Remedy, in the NHTSA record
    Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.

    Report filed by Toyota Motor Engineering & Manufacturing. Owner notification date in the NHTSA record: .

  6. 14V743000Received . 3,233 units.

    Seats / Front Assembly / Seat Heater/Cooler

    Defect, in the NHTSA record
    Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
    Consequence, in the NHTSA record
    Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
    Remedy, in the NHTSA record
    SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

    Report filed by Southeast Toyota Distributors, LLC. Owner notification date in the NHTSA record: .

  7. 13V383000Received . 780,584 units.

    Suspension / Rear

    Defect, in the NHTSA record
    Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
    Consequence, in the NHTSA record
    Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.

    Report filed by Toyota Motor Engineering & Manufacturing.

  8. 13V123000Received . 7,525 units.

    Equipment / Other / Labels

    Defect, in the NHTSA record
    Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
    Consequence, in the NHTSA record
    An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
    Remedy, in the NHTSA record
    Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

    Report filed by Southeast Toyota Distributors, LLC. Owner notification date in the NHTSA record: .

  9. 13V014000Received . 3,235 units.

    Seats

    Defect, in the NHTSA record
    Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
    Consequence, in the NHTSA record
    If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
    Remedy, in the NHTSA record
    Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

    Report filed by Southeast Toyota Distributors, LLC. Owner notification date in the NHTSA record: .

  10. 12V373000Received . 780,584 units.

    Suspension / Rear

    Defect, in the NHTSA record
    Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
    Consequence, in the NHTSA record
    Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.

    Report filed by Toyota Motor Engineering & Manufacturing. Owner notification date in the NHTSA record: .

  11. 12V029000Received . 427 units.

    Air Bags / Side/Window

    Defect, in the NHTSA record
    Toyota is recalling certain model year 2011 rav4 vehicles, manufactured from november 24, 2011, through december 19, 2011. In the curtain shield airbags, propellant with the incorrect specification was used for the initiator assembled in the airbag inflator. In this condition, the inflator may not perform properly, causing one or both curtain shield airbags to not deploy.
    Consequence, in the NHTSA record
    In the event of a crash, the airbags may not deploy and will not be able to properly protect an occupant, increasing the risk of injuries.
    Remedy, in the NHTSA record
    Toyota will notify owners, and dealers will check the vehicle identification number to identify the curtain shield assemblies and replace the assemblies as necessary with new ones free of charge. The safety recall began on march 8, 2012. Owners may contact toyota at 1-800-331-4331.

    Report filed by Toyota Motor Engineering & Manufacturing. Owner notification date in the NHTSA record: .

The campaign number opens the NHTSA record. Each quotation is the text of the NHTSA recall file.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

Complaints by component

The NHTSA complaint file has no complaint for this model year.

Investigations

NHTSA investigations that name the 2011 Toyota RAV4
NumberTypeSubjectComponentOpenedClosedCampaign
EQ12002InvestigationAutoliv Air Bag Propellant MixtureAir Bags / Side/Window14 Feb 20128 May 2012

Investigation: A study of a possible safety defect by the NHTSA Office of Defects Investigation. An investigation with no closing date in the NHTSA file is open.

Other model years

The number under each year is the number of recall campaigns.

  1. 19940
  2. 19960
  3. 19970
  4. 19984
  5. 19994
  6. 20003
  7. 20010
  8. 20020
  9. 20030
  10. 20042
  11. 20055
  12. 200611
  13. 200714
  14. 200814
  15. 200915
  16. 201014
  17. 201111
  18. 20125
  19. 20132
  20. 20144
  21. 20154
  22. 20163
  23. 20173
  24. 20183
  25. 20197
  26. 20206
  27. 20211
  28. 20221
  29. 20233
  30. 20243
  31. 20253

A year without a link has fewer than 2 campaigns and fewer than 25 complaints. It has no page.

Official channels

Cite this page

Recall Register. 2011 Toyota RAV4: recalls and complaints. https://recallregister.com/vehicle/toyota/rav4/2011/. Source: NHTSA Office of Defects Investigation, recall, complaint and investigation files. Data through .

Sources

Source
NHTSA Office of Defects Investigation
Licence
US government work, public domain
Recall file through
30 Sep 2026
Complaint file through
29 Mar 2018
First complaint in the file
1 Jan 1995
Manufacturer in the recall file
Toyota Motor Engineering & Manufacturing

The NHTSA record is the authority. A complaint count is the number of different complaint numbers for the make, the model and the model year. How the register is made. Report an error.

Questions

How many units are in the recall campaigns for the 2011 Toyota RAV4?
5,282,278 units in 11 campaigns. A campaign can name other models and model years, and its units include them.
How many recall campaigns does the Toyota RAV4 have for all model years?
NHTSA lists 50 recall campaigns for the Toyota RAV4, model years 1994 to 2025. 11 of them name the 2011 model year.
Is an NHTSA investigation of the 2011 Toyota RAV4 open?
No. The 1 investigation that names this model year has a closing date in the NHTSA file.