Recall Register

2003 Itasca Sunova: recalls and complaints

NHTSA lists 7 recall campaigns for the 2003 Itasca Sunova. The newest campaign is 10V525000. NHTSA received the report on 26 Oct 2010. The NHTSA record gives the component Equipment. NHTSA has 4 complaints on file for this model year.

The NHTSA recall file shows no do-not-drive advisory and no park-outside advisory on these campaigns.

This page cannot show if a recall applies to one vehicle. The NHTSA VIN lookup shows the unrepaired recalls of one vehicle.

Remedy of the newest campaign, 10V525000, in the NHTSA record

Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
NHTSA VIN lookup

Complaint information entered into NHTSA’s Office of Defects Investigation vehicle owner's complaint database is used with other data sources to identify safety issues that warrant investigation and to determine if a safety-related defect trend exists.

NHTSA publishes these words. Source: NHTSA Datasets and APIs, section Complaints, read on . Complaint file through . Recall file through .

Since the last update

No tracked figure of this page changed in a data update. What the log tracks

All updates to the register

Recall campaigns

7 campaigns, newest first. 54,373 units in total.

  • 10V525000Equipment
  • 04V609000Fuel System, Gasoline / Delivery / Hoses, Lines/Piping, and Fittings
  • 04V358000Equipment / Recreational Vehicle/Trailer
  • 03V405000Equipment / Recreational Vehicle/Trailer
  • 03V243000Equipment / Recreational Vehicle/Trailer
  • 03V060000Service Brakes, Hydraulic / Brake Fluid Low Warning / Lamp
  • 03V049000Tires / Temporary/Emergency Spare Tire

  1. 10V525000Received . 18,461 units.

    Equipment

    Defect, in the NHTSA record
    Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
    Consequence, in the NHTSA record
    The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
    Remedy, in the NHTSA record
    Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.

    Report filed by WINNEBAGO INDUSTRIES, INC.. Owner notification date in the NHTSA record: .

  2. 04V609000Received . 3,538 units.

    Fuel System, Gasoline / Delivery / Hoses, Lines/Piping, and Fittings

    Defect, in the NHTSA record
    On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
    Consequence, in the NHTSA record
    Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
    Remedy, in the NHTSA record
    Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1-800-537-1885.

    Report filed by WINNEBAGO INDUSTRIES, INC.. Manufacturer campaign number 93. Owner notification date in the NHTSA record: .

  3. 04V358000Received . 5,645 units.

    Equipment / Recreational Vehicle/Trailer

    Defect, in the NHTSA record
    On certain motor homes equipped with samsung microwave ovens, models mr1031wb, mr1032bb, mr1033sb, mr1351wb, and mr1352bb, the microwaves were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
    Consequence, in the NHTSA record
    An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
    Remedy, in the NHTSA record
    Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 1-800-932-3837 or winnebago at 1-641-585-3535.

    Report filed by WINNEBAGO INDUSTRIES, INC..

  4. 03V405000Received . 15,337 units.

    Equipment / Recreational Vehicle/Trailer

    Defect, in the NHTSA record
    On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
    Consequence, in the NHTSA record
    An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
    Remedy, in the NHTSA record
    Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or winnebago at 641-585-3535.

    Report filed by WINNEBAGO INDUSTRIES, INC..

  5. 03V243000Received . 2,684 units.

    Equipment / Recreational Vehicle/Trailer

    Defect, in the NHTSA record
    On certain motor homes, when the cooking range and furnace are operating at the same time, the flame on the cooking range could be forced downward over the burner or flame outage could occur. This condition is due to the location of the furnace and cooking range whereby the furnace may draw air in from above the range burners and cause a downdraft.
    Consequence, in the NHTSA record
    Should this occur, the flame may go out, and the liquid propane (lp) gas will continue to flow. This is a hazardous situation that could result in an explosion or fire.
    Remedy, in the NHTSA record
    Dealers will install an air restrictor panel under the range. Owner notification began july 10, 2003. Owners should contact winnebago at 1-641-585-6939.

    Report filed by WINNEBAGO INDUSTRIES, INC.. Manufacturer campaign number 89. Owner notification date in the NHTSA record: .

  6. 03V060000Received . 8,532 units.

    Service Brakes, Hydraulic / Brake Fluid Low Warning / Lamp

    Defect, in the NHTSA record
    Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105,"hydraulic and electric brake systems." the brake system warning indicator may not function as required by the standard.
    Consequence, in the NHTSA record
    In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the system warning indicator.
    Remedy, in the NHTSA record
    Dealers will repair these vehicles. Owner notification began april 25, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-3535.

    Report filed by WINNEBAGO INDUSTRIES, INC.. Manufacturer campaign number 88. Owner notification date in the NHTSA record: .

  7. 03V049000Received . 176 units.

    Tires / Temporary/Emergency Spare Tire

    Defect, in the NHTSA record
    On certain model d30b motor homes built on a ford chassis, a plate, which is used to support the spare tire, was inadvertently left off a number of these motor homes.
    Consequence, in the NHTSA record
    Without this additional support, the spare tire could fall off the vehicle resulting in property damage and possibly personal injury.
    Remedy, in the NHTSA record
    Dealers will inspect the spare tire mount and, if necessary, install a new support plate. Owner notification is expected to begin during march 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-6939.

    Report filed by WINNEBAGO INDUSTRIES, INC.. Manufacturer campaign number 87. Owner notification date in the NHTSA record: .

The campaign number opens the NHTSA record. Each quotation is the text of the NHTSA recall file.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

Complaints by component

4 complaints, 8 component mentions.

A complaint can name more than one component. Each component that a complaint names is one component mention. This model year has fewer than 50 component mentions, so the table shows the number of mentions only.

2003 Itasca Sunova: component mentions in complaints
ComponentMentions
Electrical System3
Tires1
Latches/Locks/Linkages1
Service Brakes, Hydraulic1
Parking Brake1
Service Brakes1
Complaints that report a crash
0
Complaints that report a fire
1
Injuries in the complaints
0
Deaths in the complaints
0
Date of the newest complaint
18 Oct 2012

These figures are the entries of the persons who sent the complaints.

Complaint: A report about a possible safety problem that a person sends to NHTSA. This site shows the number of complaints and not their text.

Complaints about the 2003 Itasca Sunova, by the year NHTSA received them. The largest year is 2011, with 2 complaints.

Investigations

The NHTSA investigation file has no investigation that names this model year.

Investigation: A study of a possible safety defect by the NHTSA Office of Defects Investigation. An investigation with no closing date in the NHTSA file is open.

Other model years

The number under each year is the number of recall campaigns.

  1. 19961
  2. 19971
  3. 19981
  4. 19991
  5. 20002
  6. 20013
  7. 20024
  8. 20037
  9. 20046
  10. 20054
  11. 20067
  12. 20076
  13. 20084
  14. 20095
  15. 20102
  16. 20112
  17. 20123
  18. 20134
  19. 20144
  20. 20154
  21. 20166
  22. 20173
  23. 20183
  24. 20191

A year without a link has fewer than 2 campaigns and fewer than 25 complaints. It has no page.

Official channels

Cite this page

Recall Register. 2003 Itasca Sunova: recalls and complaints. https://recallregister.com/vehicle/itasca/sunova/2003/. Source: NHTSA Office of Defects Investigation, recall, complaint and investigation files. Data through .

Sources

Source
NHTSA Office of Defects Investigation
Licence
US government work, public domain
Recall file through
29 Sep 2026
Complaint file through
15 May 2019
First complaint in the file
1 Jan 1995
Manufacturer in the recall file
WINNEBAGO INDUSTRIES, INC.

The NHTSA record is the authority. A complaint count is the number of different complaint numbers for the make, the model and the model year. How the register is made. Report an error.

Questions

How many units are in the recall campaigns for the 2003 Itasca Sunova?
54,373 units in 7 campaigns. A campaign can name other models and model years, and its units include them.
How many recall campaigns does the Itasca Sunova have for all model years?
NHTSA lists 28 recall campaigns for the Itasca Sunova, model years 1996 to 2019. 7 of them name the 2003 model year.
Which component do the complaints about the 2003 Itasca Sunova name most often?
Electrical System: 3 of 8 component mentions.
Is an NHTSA investigation of the 2003 Itasca Sunova open?
The NHTSA investigation file has no investigation that names this model year.