Recall Register

2010 International Prostar: recalls and complaints

NHTSA lists 10 recall campaigns for the 2010 International Prostar. The newest campaign is 23V353000. NHTSA received the report on 18 May 2023. The NHTSA record gives the component Exterior Lighting / Back Up Lights. NHTSA has 7 complaints on file for this model year.

The NHTSA recall file shows no do-not-drive advisory and no park-outside advisory on these campaigns.

This page cannot show if a recall applies to one vehicle. The NHTSA VIN lookup shows the unrepaired recalls of one vehicle.

Remedy of the newest campaign, 23V353000, in the NHTSA record

Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
NHTSA VIN lookup

Complaint information entered into NHTSA’s Office of Defects Investigation vehicle owner's complaint database is used with other data sources to identify safety issues that warrant investigation and to determine if a safety-related defect trend exists.

NHTSA publishes these words. Source: NHTSA Datasets and APIs, section Complaints, read on . Complaint file through . Recall file through .

Since the last update

No tracked figure of this page changed in a data update. What the log tracks

All updates to the register

Recall campaigns

10 campaigns, newest first. 178,421 units in total.

  • 23V353000Exterior Lighting / Back Up Lights
  • 14V688000Electrical System
  • 13V439000Equipment
  • 12V196000Electrical System / Alternator/Generator/Regulator
  • 11V426000Electrical System / Alternator/Generator/Regulator
  • 10V383000Visibility / Rear Window Wiper/Washer / Linkages
  • 10V259000Steering / Gear Box / Shaft Pitman
  • 10V107000Electrical System / 12v/24v/48v Battery
  • 10V037000Electronic Stability Control (ESC)
  • 08V618000Service Brakes, Air / Supply / Hoses, Lines/Piping, and Fittings

  1. 23V353000Received . 32,880 units.

    Exterior Lighting / Back Up Lights

    Defect, in the NHTSA record
    Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
    Consequence, in the NHTSA record
    Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.

    Report filed by Navistar, Inc.. Manufacturer campaign number 23514. Owner notification date in the NHTSA record: .

  2. 14V688000Received . 18,798 units.

    Electrical System

    Defect, in the NHTSA record
    Navistar, Inc. (Navistar) is recalling certain model year 2010-2015 International Lonestar vehicles manufactured October 12, 2009, to June 16, 2014, and 2009-2015 International ProStar vehicles manufactured December 16, 2008, to June 20, 2014. In the affected vehicles the electrical harness that supplies power to the HVAC system may not be of sufficient size for the electrical load of the circuit. This can result in an increase in resistance and heating at the connectors.
    Consequence, in the NHTSA record
    An increase in resistance and heating at the connectors could cause a vehicle fire.
    Remedy, in the NHTSA record
    Navistar will notify owners, and dealers will replace the 60 amp relay and battery harness with a 150 amp relay and battery harness, free of charge. Navistar issued an interim notification to owners on December 29, 2014. The recall began on March 2, 2015. Owners may contact Navistar customer service at 1-331-332-1590. Navistar's number for this recall is 14516.

    Report filed by Navistar, Inc.. Manufacturer campaign number 14516. Owner notification date in the NHTSA record: .

  3. 13V439000Received . 16,107 units.

    Equipment

    Defect, in the NHTSA record
    Navistar, Inc. is recalling certain model year 2008-2013 International LoneStar, ProStar, and TranStar trucks manufactured February 20, 2008, through July 29, 2013 and equipped with an electronic fifth wheel jaw release system (feature code 0595BAW or 0595BAY). Due to an assembly error, the air lines at the isolation/vent valve may not be oriented correctly.
    Consequence, in the NHTSA record
    Because of the improper orientation, in the event of an air leakage at the isolation/vent valve, the 5th wheel jaw may release, unexpectedly releasing the trailer from the tractor, increasing the risk of a vehicle crash.
    Remedy, in the NHTSA record
    Navistar will notify owners, and dealers will inspect the air line routing. If necessary, the air line routing will be corrected free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1-331-332-1590. Navistar's recall number is 13514.

    Report filed by Navistar, Inc.. Manufacturer campaign number 13514.

  4. 12V196000Received . 19,264 units.

    Electrical System / Alternator/Generator/Regulator

    Defect, in the NHTSA record
    Navistar is recalling certain model year 2010 through 2013 paystar, workstar, transtar, and prostar, and model year 2012 and 2013 lonestar commercial trucks manufactured from june 1, 2009, through april 4, 2012, equipped with a maxxforce 11 or 13 engine (feature code 12uxj or 12uxh) and with bosch alternator feature codes 08ggn, 08ggr, 08ghg, or 08ghh. The alternator cable may rub on the high pressure power steering hose, possibly chafing its insulation and causing an electrical short.
    Consequence, in the NHTSA record
    An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death.
    Remedy, in the NHTSA record
    Navistar will install a standoff bracket and improve harness routing to better route the alternator wires away from the power steering hose. The safety recall began on july 16, 2012. Owners may contact navistar at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 12515. Owner notification date in the NHTSA record: .

  5. 11V426000Received . 5,663 units.

    Electrical System / Alternator/Generator/Regulator

    Defect, in the NHTSA record
    Navistar is recalling certain model year 2010-2012 paystar, workstar, transtar, and prostar commercial trucks manufactured from june 1, 2009, through may 31, 2011, equipped with a maxxforce 11 or 13 engine (feature code 12uxj or 12uxh) and with alternator feature code 08ggn, 08ggr, 08 ghg, or 08ghh. The alternator cable may rub on the high pressure power steering hose, possibly chafing its insulation and causing an electrical short.
    Consequence, in the NHTSA record
    An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death.
    Remedy, in the NHTSA record
    Navistar will install a bracket to route the wires away from the power steering hose. Navistar did not provide an expected start date for the recall, but an interim notice will be mailed to owners if parts will not be available until after october 14, 2011. Owners may contact navistar at 1-800-448-7825. This recall campaign has been superseded by 12v-196.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 11516. Owner notification date in the NHTSA record: .

  6. 10V383000Received . 39,544 units.

    Visibility / Rear Window Wiper/Washer / Linkages

    Defect, in the NHTSA record
    Navistar is recalling certain model year 2008 through 2011 international prostar and lonestar heavy trucks manufactured from january 2, 2007 through june 1, 2010. The passenger side windshield wiper linkage rod may separate from either the wiper drive arm or passenger side pivot assembly.
    Consequence, in the NHTSA record
    When the linkage separates, the passenger side wiper arm will no longer operate which could lead to reduced driver visibility, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Navistar will notify owners and international dealers will replace the windshield wiper linkage assembly free of charge. The safety recall is expected to begin on or about december 17, 2010. Owners may contact navistar at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 10514. Owner notification date in the NHTSA record: .

  7. 10V259000Received . 1,220 units.

    Steering / Gear Box / Shaft Pitman

    Defect, in the NHTSA record
    Navistar is recalling certain model year 2010 and 2011 international 4300m, 8600, lonestar and prostar brand trucks manufactured from may 6, 2009 through may 25, 2010. The fastener that clamps the pitman arm to the steering gear shaft may have been undertorqued upon assembly. An under torque condition may cause wear of the interconnecting splines of the arm and the shaft possibly allowing the pitman arm to slip over the shaft resulting in a reduction of steering control.
    Consequence, in the NHTSA record
    A reduction of steering control increases the risk of a crash.
    Remedy, in the NHTSA record
    Navistar will notify owners and dealers will repair the vehicles free of charge. The safety recall began on july 9, 2010. Owners may contact navistar at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 10511. Owner notification date in the NHTSA record: .

  8. 10V107000Received . 29,460 units.

    Electrical System / 12v/24v/48v Battery

    Defect, in the NHTSA record
    Navistar has notified NHTSA of a defect on certain model year 2008-2011 international trucks equipped with an optional jump start stud. Corrosion at the base of the stud may cause an electrical short between the stud and battery box.
    Consequence, in the NHTSA record
    An electrical short may cause a vehicle fire.
    Remedy, in the NHTSA record
    A final remedy has been established. Navistar will notify owners, and dealers will repair the vehicles by installing a new jump start stud. Repairs will be preformed free of charge. An interim action will involve the removal of the jump start stud and the connecting cable. The safety recall began on september 10, 2010. Owners may contact international dealers at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 10506. Owner notification date in the NHTSA record: .

  9. 10V037000Received . 1,437 units.

    Electronic Stability Control (ESC)

    Defect, in the NHTSA record
    Navistar is recalling certain model year 2009-2010 international prostar and lonestar trucks equipped with feature code 04azt roll stability control. The air line that supplies the traction solenoid valve of the roll stability control (rsc) system may have been connected to an incorrect port on the air tank. This condition will affect air modulation to the trailer brakes if rsc is activated during a roll stability event. This condition at no time affects the normal design function of the tractor and trailer service brakes when activated by the driver, or the function of the tractor rsc system.
    Consequence, in the NHTSA record
    Less than optimal rsc control of the trailer brakes during a roll stability event may increase the risk of a crash which can result in property damage, personal injury, or death.
    Remedy, in the NHTSA record
    Dealers will inspect and relocate the air line that supplies the rsc traction solenoid valve to the correct port on the air tank. This service will be performed free of charge. The safety recall began on february 19, 2010. Owners may contact navistar at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 10503. Owner notification date in the NHTSA record: .

  10. 08V618000Received . 14,048 units.

    Service Brakes, Air / Supply / Hoses, Lines/Piping, and Fittings

    Defect, in the NHTSA record
    Navistar is recalling 14,048 my 2008-2010 lonestar and prostar trucks. The service brake air line that runs from the tractor protection valve to the fast brake module may separate from the fast brake module resulting in loss of trailer service brakes.
    Consequence, in the NHTSA record
    Loss of trailer service brakes may cause a crash resulting in possible property damage, personal injury, or death.
    Remedy, in the NHTSA record
    Dealers will replace the fast brake modules and the air lines running to the module will be rerouted to eliminate line tension caused by cab to frame relative motion. The recall began on march 20, 2009. Owners may contact navistar at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 08510. Owner notification date in the NHTSA record: .

The campaign number opens the NHTSA record. Each quotation is the text of the NHTSA recall file.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

Complaints by component

7 complaints, 11 component mentions.

A complaint can name more than one component. Each component that a complaint names is one component mention. This model year has fewer than 50 component mentions, so the table shows the number of mentions only.

2010 International Prostar: component mentions in complaints
ComponentMentions
Engine and Engine Cooling3
Service Brakes, Hydraulic1
Steering1
Unknown or Other1
Service Brakes1
Visibility/Wiper1
Electrical System1
Engine1
Fuel/Propulsion System1
Complaints that report a crash
1
Complaints that report a fire
1
Injuries in the complaints
2
Deaths in the complaints
0
Date of the newest complaint
20 Dec 2020

These figures are the entries of the persons who sent the complaints.

Complaint: A report about a possible safety problem that a person sends to NHTSA. This site shows the number of complaints and not their text.

Complaints about the 2010 International Prostar, by the year NHTSA received them. The largest year is 2010, with 2 complaints.

Investigations

The NHTSA investigation file has no investigation that names this model year.

Investigation: A study of a possible safety defect by the NHTSA Office of Defects Investigation. An investigation with no closing date in the NHTSA file is open.

Other model years

The number under each year is the number of recall campaigns.

  1. 20021
  2. 20031
  3. 20041
  4. 20051
  5. 20061
  6. 20073
  7. 20089
  8. 20099
  9. 201010
  10. 201115
  11. 201218
  12. 201318
  13. 201410
  14. 20157
  15. 20168
  16. 20179
  17. 20186
  18. 20193
  19. 20221

A year without a link has fewer than 2 campaigns and fewer than 25 complaints. It has no page.

Official channels

Cite this page

Recall Register. 2010 International Prostar: recalls and complaints. https://recallregister.com/vehicle/international/prostar/2010/. Source: NHTSA Office of Defects Investigation, recall, complaint and investigation files. Data through .

Sources

Source
NHTSA Office of Defects Investigation
Licence
US government work, public domain
Recall file through
30 Sep 2026
Complaint file through
30 Sep 2026
First complaint in the file
1 Jan 1995
Manufacturer in the recall file
Navistar, Inc.

The NHTSA record is the authority. A complaint count is the number of different complaint numbers for the make, the model and the model year. How the register is made. Report an error.

Questions

How many units are in the recall campaigns for the 2010 International Prostar?
178,421 units in 10 campaigns. A campaign can name other models and model years, and its units include them.
How many recall campaigns does the International Prostar have for all model years?
NHTSA lists 50 recall campaigns for the International Prostar, model years 2002 to 2022. 10 of them name the 2010 model year.
Which component do the complaints about the 2010 International Prostar name most often?
Engine and Engine Cooling: 3 of 11 component mentions.
Is an NHTSA investigation of the 2010 International Prostar open?
The NHTSA investigation file has no investigation that names this model year.