Recall Register

2001 Thomas Transit Liner ER: recalls and complaints

NHTSA lists 3 recall campaigns for the 2001 Thomas Transit Liner ER. The newest campaign is 02V320000. NHTSA received the report on 2 Dec 2002. The NHTSA record gives the component Suspension / Rear / Springs / Air Suspension System. NHTSA has no complaint on file for this model year.

The NHTSA recall file shows no do-not-drive advisory and no park-outside advisory on these campaigns.

This page cannot show if a recall applies to one vehicle. The NHTSA VIN lookup shows the unrepaired recalls of one vehicle.

Remedy of the newest campaign, 02V320000, in the NHTSA record

Dealers will install axle stops to limit rear suspension travel and fastener torque will be checked on the suspension height control rod. Owner notification is expected to begin during february 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
NHTSA VIN lookup

Complaint information entered into NHTSA’s Office of Defects Investigation vehicle owner's complaint database is used with other data sources to identify safety issues that warrant investigation and to determine if a safety-related defect trend exists.

NHTSA publishes these words. Source: NHTSA Datasets and APIs, section Complaints, read on . Complaint file through . Recall file through .

Since the last update

No tracked figure of this page changed in a data update. What the log tracks

All updates to the register

Recall campaigns

3 campaigns, newest first. 413 units in total.

  1. 02V320000Received . 122 units.

    Suspension / Rear / Springs / Air Suspension System

    Defect, in the NHTSA record
    On certain school and transit buses equipped with reyco rear axle air suspensions, deflated suspension air bags could create excessive driveline angles causing u-joint damage.
    Consequence, in the NHTSA record
    The drive shaft could fall off of the bus. Following vehicles could then run over this obstacle, increasing the risk of damage to the following vehicle.
    Remedy, in the NHTSA record
    Dealers will install axle stops to limit rear suspension travel and fastener torque will be checked on the suspension height control rod. Owner notification is expected to begin during february 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.

    Report filed by FREIGHTLINER CORPORATION. Owner notification date in the NHTSA record: .

  2. 01V104000Received . 145 units.

    Structure / Body

    Defect, in the NHTSA record
    Vehicle description: certain school buses built with composite front roof caps fail to comply with requirements of FMVSS no. 221, "school bus body joint strength." the roof cap does not meet the requirements due to the omission of the adhesive that joins the roof to the bus body.
    Consequence, in the NHTSA record
    In the event of a crash, the roof of the vehicle may crush, not properly protecting the vehicle occupants.
    Remedy, in the NHTSA record
    Dealers will re-bond the roof cap to the roof sheet metal. Owner notification began september 14, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-889-4871.

    Report filed by FREIGHTLINER CORPORATION. Owner notification date in the NHTSA record: .

  3. 01V103000Received . 146 units.

    Vehicle Speed Control / Accelerator Pedal

    Defect, in the NHTSA record
    Vehicle description: school buses. The accelerator pedal can possibly hang up on the floor rubber.
    Consequence, in the NHTSA record
    The driver would be expecting the vehicle's speed to decrease, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Dealers will install a stainless steel plate under the accelerator pedal. Owner notification began june 8, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-889-4871.

    Report filed by FREIGHTLINER CORPORATION. Owner notification date in the NHTSA record: .

The campaign number opens the NHTSA record. Each quotation is the text of the NHTSA recall file.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

Complaints by component

The NHTSA complaint file has no complaint for this model year.

Investigations

The NHTSA investigation file has no investigation that names this model year.

Investigation: A study of a possible safety defect by the NHTSA Office of Defects Investigation. An investigation with no closing date in the NHTSA file is open.

Other model years

The number under each year is the number of recall campaigns.

  1. 20003
  2. 20013

A year without a link has fewer than 2 campaigns and fewer than 25 complaints. It has no page.

Official channels

Cite this page

Recall Register. 2001 Thomas Transit Liner ER: recalls and complaints. https://recallregister.com/vehicle/thomas/transit-liner-er/2001/. Source: NHTSA Office of Defects Investigation, recall, complaint and investigation files. Data through .

Sources

Source
NHTSA Office of Defects Investigation
Licence
US government work, public domain
Recall file through
30 Sep 2026
Complaint file through
29 Mar 2018
First complaint in the file
1 Jan 1995
Manufacturer in the recall file
FREIGHTLINER CORPORATION

The NHTSA record is the authority. A complaint count is the number of different complaint numbers for the make, the model and the model year. How the register is made. Report an error.

Questions

How many units are in the recall campaigns for the 2001 Thomas Transit Liner ER?
413 units in 3 campaigns. A campaign can name other models and model years, and its units include them.
How many recall campaigns does the Thomas Transit Liner ER have for all model years?
NHTSA lists 4 recall campaigns for the Thomas Transit Liner ER, model years 2000 to 2001. 3 of them name the 2001 model year.
Is an NHTSA investigation of the 2001 Thomas Transit Liner ER open?
The NHTSA investigation file has no investigation that names this model year.