Recall Register

2009 International 4400: recalls and complaints

NHTSA lists 4 recall campaigns for the 2009 International 4400. The newest campaign is 23V353000. NHTSA received the report on 18 May 2023. The NHTSA record gives the component Exterior Lighting / Back Up Lights. NHTSA has no complaint on file for this model year.

The NHTSA recall file shows no do-not-drive advisory and no park-outside advisory on these campaigns.

This page cannot show if a recall applies to one vehicle. The NHTSA VIN lookup shows the unrepaired recalls of one vehicle.

Remedy of the newest campaign, 23V353000, in the NHTSA record

Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
NHTSA VIN lookup

Complaint information entered into NHTSA’s Office of Defects Investigation vehicle owner's complaint database is used with other data sources to identify safety issues that warrant investigation and to determine if a safety-related defect trend exists.

NHTSA publishes these words. Source: NHTSA Datasets and APIs, section Complaints, read on . Complaint file through . Recall file through .

Since the last update

No tracked figure of this page changed in a data update. What the log tracks

All updates to the register

Recall campaigns

4 campaigns, newest first. 70,838 units in total.

  • 23V353000Exterior Lighting / Back Up Lights
  • 10V107000Electrical System / 12v/24v/48v Battery
  • 09V101000Engine and Engine Cooling / Cooling System / Fan
  • 08V619000Suspension / Front

  1. 23V353000Received . 32,880 units.

    Exterior Lighting / Back Up Lights

    Defect, in the NHTSA record
    Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
    Consequence, in the NHTSA record
    Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
    Remedy, in the NHTSA record
    Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.

    Report filed by Navistar, Inc.. Manufacturer campaign number 23514. Owner notification date in the NHTSA record: .

  2. 10V107000Received . 29,460 units.

    Electrical System / 12v/24v/48v Battery

    Defect, in the NHTSA record
    Navistar has notified NHTSA of a defect on certain model year 2008-2011 international trucks equipped with an optional jump start stud. Corrosion at the base of the stud may cause an electrical short between the stud and battery box.
    Consequence, in the NHTSA record
    An electrical short may cause a vehicle fire.
    Remedy, in the NHTSA record
    A final remedy has been established. Navistar will notify owners, and dealers will repair the vehicles by installing a new jump start stud. Repairs will be preformed free of charge. An interim action will involve the removal of the jump start stud and the connecting cable. The safety recall began on september 10, 2010. Owners may contact international dealers at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 10506. Owner notification date in the NHTSA record: .

  3. 09V101000Received . 7,521 units.

    Engine and Engine Cooling / Cooling System / Fan

    Defect, in the NHTSA record
    Navistar is recall 7,521 my 2009 international model trucks and my 2009 and 2010 ic school and transit buses manufactured from april 1, 2008 to december 12, 2008, equipped with a horton 2-speed fan drive, identified by feature code 12tht. The fasteners that connect the magnet brackets to the air chamber housing of the 2-speed engine fan could fail resulting in the magnet bracket being thrown from the fan drive and the vehicle at high speed.
    Consequence, in the NHTSA record
    The bracket could separate and strike a person or motor vehicle resulting in property damage, personal injury, and/or death.
    Remedy, in the NHTSA record
    Navistar will notify owners and repair the vehicles by replacing the engine fan drive air chamber and magnet brackets free of charge. The safety recall is expected to begin on or about june 1, 2009. Owners may contact navistar toll-free at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 09502. Owner notification date in the NHTSA record: .

  4. 08V619000Received . 977 units.

    Suspension / Front

    Defect, in the NHTSA record
    Navistar is recalling 977 my 2009 international 3200, 4100, 4300, 4400 trucks and ic bus hc commercial buses. The front axle bearings in some cases were not sufficiently lubricated during assembly which may result in bearing seizing or possible wheel separation.
    Consequence, in the NHTSA record
    A seized bearing on the front axle could result in a vehicle crash which may result in property damage, personal injury, or death.
    Remedy, in the NHTSA record
    Dealers will inspect the front axle bearings. Bearings will be lubricated and replaced if required. The recall began on december 19, 2008. Owners may contact navistar at 1-800-448-7825.

    Report filed by NAVISTAR, INC. Manufacturer campaign number 08511. Owner notification date in the NHTSA record: .

The campaign number opens the NHTSA record. Each quotation is the text of the NHTSA recall file.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

Complaints by component

The NHTSA complaint file has no complaint for this model year.

Investigations

The NHTSA investigation file has no investigation that names this model year.

Investigation: A study of a possible safety defect by the NHTSA Office of Defects Investigation. An investigation with no closing date in the NHTSA file is open.

Other model years

The number under each year is the number of recall campaigns.

  1. 19971
  2. 19981
  3. 19991
  4. 20029
  5. 20034
  6. 20043
  7. 20054
  8. 20063
  9. 20074
  10. 20082
  11. 20094
  12. 20103
  13. 20113
  14. 20121
  15. 20141
  16. 20152
  17. 20163
  18. 20171

A year without a link has fewer than 2 campaigns and fewer than 25 complaints. It has no page.

Official channels

Cite this page

Recall Register. 2009 International 4400: recalls and complaints. https://recallregister.com/vehicle/international/4400/2009/. Source: NHTSA Office of Defects Investigation, recall, complaint and investigation files. Data through .

Sources

Source
NHTSA Office of Defects Investigation
Licence
US government work, public domain
Recall file through
29 Sep 2026
Complaint file through
15 May 2019
First complaint in the file
1 Jan 1995
Manufacturer in the recall file
Navistar, Inc.

The NHTSA record is the authority. A complaint count is the number of different complaint numbers for the make, the model and the model year. How the register is made. Report an error.

Questions

How many units are in the recall campaigns for the 2009 International 4400?
70,838 units in 4 campaigns. A campaign can name other models and model years, and its units include them.
How many recall campaigns does the International 4400 have for all model years?
NHTSA lists 26 recall campaigns for the International 4400, model years 1997 to 2017. 4 of them name the 2009 model year.
Is an NHTSA investigation of the 2009 International 4400 open?
The NHTSA investigation file has no investigation that names this model year.