Kelly Springfield: tire recalls

1. 02T004000Received 22 Mar 2002. 10,345 units.

   Tires / Tread/Belt

   Defect, in the NHTSA record

   Tire description: kelly armorsteel klhs load range g tires. Size 285/75r24.5 manufactured between february 25 and may 5, 2001, and tire size 295/75r22.5 manufactured between march 4 and may 12, 2001. These tires have exhibited evidence of premature tread separation.

   Consequence, in the NHTSA record

   If the tread were to separate from the carcass of the tire while the vehicle is in motion, the drive could lose control of the vehicle, possibly resulting in a vehicle crash.

   Remedy, in the NHTSA record

   Goodyear will notify its customers and replace the tires free of charge. Owner notification began april 3, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact goodyear consumer relations at 800-321-2136.

   Products named: Kelly Springfield 29575R225; Kelly Springfield 28575R245.

   Report filed by GOODYEAR TIRE & RUBBER CO. Owner notification date in the NHTSA record: 3 Apr 2002.

2. 98T002000Received 21 Apr 1998. 594,853 units.

   Tires / Sidewall

   Defect, in the NHTSA record

   Tire description: p205/70r14 and p205/70r15 tires, serial numbers beginning with "pj" and ending with a combination of 136 through 367. The tire brands involved are: big o legacy tour plus, embassy diplomat, arizonian limited edition, kelly aqua tour, ultra touring gt, telstar premium touring, laramie premium touring, jetzon ultra quad +, sears superguard ft, motomaster sk110, co-op golden mark, cordovan grand prix, shell touring 2000, multi-mile grand am, sigma supreme touring, concorde touring 9000, and summit touring tlr for both size tires. Unical touring radial and pos-a-traction tires are in size p20570r15 only. A circumferential cracking condition in the lower sidewall above the bead area can occur.

   Consequence, in the NHTSA record

   This condition can cause a premature failure of the tire.

   Remedy, in the NHTSA record

   Dealers will replace these tires free of charge to the consumer.

   Products named: Shell P20570R15; Embassy P20570R14; Pos-A-Traction P20570R15; Summit P20570R15; Unocal P20570R15; Laramie P20570R14; Sears P20570R15; Laramie P20570R15; Ultra P20570R15; Arizonian P20570R15; Embassy P20570R15; Big O P20570R15, and 24 more.

   Report filed by KELLY SPRINGFIELD TIRE CO. Owner notification date in the NHTSA record: 1 Jun 1998.

3. 94T007000Received 27 Oct 1994. 76,699 units.

   Tires / Bead

   Defect, in the NHTSA record

   An insufficient cure condition in the bead wire rubber insulation was caused by a small amount of contaminated rubber.

   Consequence, in the NHTSA record

   This can result in premature failure of the tire.

   Remedy, in the NHTSA record

   Dealers will replace the tires free of charge for 60 days from the date the customer receives the recall or 60 days from the date replacement tires are available.

   Products named: Shell P18575R14; Laramie P19575R14; Sigma P18575R14; Star P18575R14; Star P19575R14; Multi-Mile 18570R14; Concorde P19575R14; Summit P19575R14; Summit 19570R14; Big O P18575R14; Arizonian 19570R14; Big O 18570R14, and 41 more.

   Report filed by KELLY SPRINGFIELD TIRE CO.

4. 93T004000Received 16 Mar 1993. 1,558 units.

   Tires

   Defect, in the NHTSA record

   The tires were undercured.

   Consequence, in the NHTSA record

   Undercured tires suffer from premature failure, which maycause loss of vehicle control and an accident.

   Remedy, in the NHTSA record

   Replace the undercured tires.

   Products named: Kelly Springfield 75016LT.

   Report filed by KELLY SPRINGFIELD TIRE CO.

5. 93T001000Received 4 Jan 1993. 990 units.

   Tires

   Defect, in the NHTSA record

   An impression at the left edge of the serial identification number, caused by a bent serial identification tin, has damaged the tires.

   Consequence, in the NHTSA record

   The impression in the sidewall can result in prematurefailure of the tire in service.

   Remedy, in the NHTSA record

   These tires will be replaced free of charge if returned for replacement within 60 days of the date of notification.

   Products named: Kelly Springfield P16580R13 1992.

   Report filed by KELLY SPRINGFIELD TIRE CO. Owner notification date in the NHTSA record: 29 Jan 1993.

6. 92T009000Received 29 Jul 1992. 1,000 units.

   Tires

   Defect, in the NHTSA record

   Some tires were overcured because of an intermittent press cure timer malfunction.

   Consequence, in the NHTSA record

   The overcured condition can cause premature failure oftires in service, which could result in loss of vehicle control and a vehicleaccident.

   Remedy, in the NHTSA record

   Tires will be replaced free of charge within 60 days of the notification of defect.

   Products named: Kelly Springfield P23560R15.

   Report filed by KELLY SPRINGFIELD TIRE CO.

7. 91T009000Received 24 Jul 1991. 1,009 units.

   Tires / Markings

   Defect, in the NHTSA record

   Tires have incorrect tire load ranges, load, and inflation pressures marked on the sidewalls.

   Consequence, in the NHTSA record

   Tires used incorrectly are subject to premature failureand could result in a vehicle accident; tires do not comply with FMVSS 119.

   Remedy, in the NHTSA record

   Replace the incorrectly marked tires free of charge within 60 days from owner's receipt of recall notice or 60 days from date replacement tires are available to registered owners.

   Products named: Kelly Springfield LT22575R16.

   Report filed by KELLY SPRINGFIELD TIRE CO.

8. 87T008000Received 3 Jun 1987. 2,174 units.

   Tires / Sidewall

   Defect, in the NHTSA record

   A hole approximately .040 inches in diameter protruding partially through the mid sidewall area of the tire. This was caused by a drill bit protruding from the mold at the mold vent location.

   Consequence, in the NHTSA record

   This condition would result in gradual air loss causingunderinflation or sidewall carcass separation. Sudden loss of air could causevehicle crash without prior warning.

   Remedy, in the NHTSA record

   Replacement of tires at no cost to the consumer within 60 days from date of notification.

   Products named: Kelly Springfield P23575B15.

   Report filed by KELLY SPRINGFIELD TIRE CO.

9. 87T007000Received 3 Jun 1987. 91 units.

   Tires

   Defect, in the NHTSA record

   Tires failed to pass endurance test required by FMVSS 109. Tires may develop separation between the carcass and belts.

   Consequence, in the NHTSA record

   Vehicle vibration and sudden loss of air can result in avehicle crash without prior warning.

   Remedy, in the NHTSA record

   Replacement of tires at no cost to the consumer within 60 days from date of notification.

   Products named: Kelly Springfield P20575B14.

   Report filed by KELLY SPRINGFIELD TIRE CO.

10. 77T004000Received 11 Feb 1977. 664 units.

    Tires / Tread/Belt

    Defect, in the NHTSA record

    The involved tires fail to meet the high speed requirements of federal motor vehicle safety standard no. 109, "new pneumatic tires". These tires failed during the high speed test because of tread separation.

    Remedy, in the NHTSA record

    Dealer will replace involved tires, free of charge, within 60 days of recall notification.

    Products named: Kelly Springfield HR7815.

    Report filed by KELLY SPRINGFIELD TIRE CO.

11. 77T001000Received 21 Jan 1977. 680 units.

    Tires / Tread/Belt

    Defect, in the NHTSA record

    The involved tires may not meet the requirements of federal motor vehicle safety standard no. 119, "new pneumatic tires for vehicles other than passenger cars". As a result, the tread could separate from the carcass in the shoulder area of the tire while in service.

    Remedy, in the NHTSA record

    Involved tires will be replaced, free of charge, within 60 days of recall notification.

    Products named: Kelly Springfield 1200165.

    Report filed by KELLY SPRINGFIELD TIRE CO.

12. 76T001000Received 30 Jan 1976. 300,000 units.

    Tires / Tread/Belt

    Products named: Kelly Springfield HR7814; Astrostar HR7815; Traveler HR7814; All American HR7815; Cordovan HR7815; Cordovan HR7814; Atlas HR7814; Delta HR7815; Atlas HR7815; Kelly Springfield HR7815; Union 76 HR7814; Cordovan JR7815, and 28 more.

    Report filed by KELLY SPRINGFIELD TIRE CO.

13. 74T021000Received 19 Aug 1974. 1,900 units.

    Tires / Tread/Belt

    Products named: Kelly Springfield 165R15.

    Report filed by KELLY SPRINGFIELD TIRE CO.

14. 74T015000Received 15 May 1974. 200 units.

    Tires / Tread/Belt

    Products named: Kelly Springfield L7815.

    Report filed by KELLY SPRINGFIELD TIRE CO.

The campaign number opens the NHTSA record.

Recall campaign: One recall in the NHTSA recall file, with one campaign number. A campaign can name many makes, models and model years.

Units: The number of vehicles or products that a recall can include. The manufacturer or the firm reports the number to the agency.

• HR78152
• 12001651
• 165R151
• 18570R141
• 19570R141
• 28575R2451
• 29575R2251
• 75016LT1
• HR78141
• JR78151
• L78151
• LR78151
• LT22575R161
• P16580R131
• P18575R141
• P19575141
• P19575R141
• P20570R141
• P20575B141
• P23560R151
• P23575B151

• All tires brands
• Javelin2
• JC Penney5
• Jetzon3
• JTW2
• Kelly2
• Kmart3
• Kumho6
• Landsail2
• Laramie8
• Laredo2

Follow by RSS:Child seat, tire and equipment recalls

• NHTSA recall lookupNHTSA shows the recalls of a child seat, a tire or equipment by brand and model.
• NHTSA: report a safety problemThe NHTSA form for a complaint about a vehicle, a tire, a child seat or equipment.

Which Kelly Springfield products do the campaigns name?

The NHTSA records have 21 product names for these campaigns. The name in the most campaigns is: HR7815

How many units does a Kelly Springfield tire campaign have?

The median Kelly Springfield campaign has 1,558 units. The median of all 788 tire campaigns is 1,205 units.

Which component do the Kelly Springfield campaigns name most often?

Tread/Belt, in 6 campaigns. The component is the first component in the NHTSA record of a campaign.